Solar Water Heater Maintenance Checklist

Be sure to check the water draining out and make sure it is clear.

Solar water heater maintenance checklist.

Open a hot water. Annual water heater maintenance checklist drain and flush tank drain and flush tank very important for gas water heaters. With pressure valve still open turn on the water to the water tank and then turn on the water drain to allow the rest of the sediment to be flushed out. 1 temperature of hot water.

The pump should be installed so that the pump is pumping away from the hot water heater towards the solar panel. Satisfactory not satisfactory 3 constant temperature e g. Here are some suggested inspections of solar system components. Turn off cold water supply and open drain valve.

Check to make sure the water to the hot water heater has been completely shut off. Drain 2 3 gallons of water. Satisfactory not satisfactory 2 quantity of hot water supply. Regularly scheduled maintenance should include.

Solar water heating system maintenance and repair periodic inspection list. Whether the tank is gas or electric turn off its heating source the night before. Don t miss the temperature and pressure valves. When calling for assistance please have the following.

Turn off the heat. Open t p relief valve to relieve pressure. Disconnect the hot water heater at the hot water discharge. Install pump onto the water heater discharge using pipe fitting.

Close drain valve and open cold water supply valve. Among the parts that should be checked regularly on your solar water heater are pumps valves and their controls insulation wiring pipes seals and the state of the solar collector. Use a solution of dish soap and warm. Allow a few gallons worth of water to drain.

Solar storage tank water heater installation instructions and use care guide to obtain technical warranty or service assistance during or after the installation of this solar storage tank water heater reference the phone number on the warranty sheet that ships with the water heater. If that is too. If it is then you are set to refill the tank. If water is milky drain entire tank.

Drain the water from the hot water pipe. Two major factors affecting the performance of properly sited and installed solar. Also read your owner s manual. Before you begin inspect all of the valves.

Checking the solar collectors and frames for damage noting broken or leaking tubes for replacement ensuring valves are in proper positions inspecting pipe insulation to minimize losses and maintain freeze protection checking mounting connectors for.